A subscriber sent this Beacon generator to me I think as a challenge. It is in bad condition. After sorting out the engine issues in part 1, I could see that the generator was not making power. I found damage on the power control board (PCB). The stator and rotor tested well so I sent the PCB out for repair. Upon installing the repaired board the generator made power, but the silicon controlled rectifier (SCR) immediately blew out and the engine went under a heavy load. The board failed in the same way as I found it before sending it for repair. I tested the insulation at 1000 volts and did not find a fault. I am going try my luck one more time and get the PCB repaired again.

Beacon Part 1:    • Will it Run and Make Power?  Beacon ...  
PCB Board Repair 1:    • Briggs / Generac Power Regulator Boar...  
PCB Board Repair 2:    • Portable Generator 84132GS Power Regu...  
Bassguitarist1985 (aka Gary):    / @bassguitarist1985  

Generator Model: 012770
Engine Model: GN410 EHF041081
Power Control Board (PCB) Part Number: 84132GS
System Control Board (SCB) Part Number: 83970GS

I use Harbor Freight Super Heavy Duty Degreaser in my ultrasonic cleaner.

Visit My Amazon Store:
https://www.amazon.com/shop/jamescondon

3 Jaw Puller: https://amzn.to/3AEXyag
Anti Lash Spring: https://amzn.to/3VpmdaG
Caliper: https://amzn.to/3V3aXkM
Dead Blow Hammer: https://amzn.to/3B2K3BJ
Lab Power Supply: https://amzn.to/3GESJl4
Oil Filter: https://amzn.to/3GFMJsk
PB Blaster: https://amzn.to/3i0UgYp
Scissor Jack: https://amzn.to/3tW4w70
Squeeze Bottle: https://amzn.to/3iaiwHB
Test Light: https://amzn.to/3AEy650
Tygon Fuel Line: https://amzn.to/3XprQaX

If you want to donate to the channel, you can use the YouTube "Super Thanks" feature.

#GeneratorRepair #SmallEngineRepair #SmallEngine #DIY #Fixed #Troubleshooting #HowTo #Generac

01277, 012770, 5500EXL, 5500XL, 7550EXL, 7550XL, 83970GS, 84132GS, Anti Lash Spring, Anti Surge Spring, Bad Excitation Winding, Bad Stator, Beacon Group, Beacon, EHF041081, Engine Goes Under Load, Fire, Fixed, Flying Short, GN410, Generac EXL, Generac XL, Generac, Generator, Hertz, How To, HowTo, No Output, No Power, No Voltage, Oil Pressure Test, PCB, Power Control Board, Rotor Removal, Rotor Test, SCB, SCR, Small Engine, Smoke, Stator Removal, System Control Board, Troubleshooting, Voltage Regulator